Com Unit for FOUNDATION Fieldbus Modular I/O FB8210*

Interface between the I/O modules and the PCS/PLC
Com unit for 20 analog or 40 digital channels
Communication via FOUNDATION Fieldbus H1
HART communication via service bus
Configured via the process control system
Non-volatile memory for configuration and parameter settings
Quick communication set-up
Permanently self-monitoring
Outputs drive to safe state in case of failures
Supports multichannel I/O modules
Installation in suitable enclosures in Zone 1 or Zone 21
Module can be exchanged under voltage (hot swap)
Installation in suitable enclosures in Zone 1

Technical Data
Informative Literature
Product Documentation
Design / Simulation
Approvals
Software
관련문서
전문가 상담

Please note: All product-related documents, such as certificates, declarations of conformity, etc., which were issued prior to the conversion under the name Pepperl+Fuchs GmbH or Pepperl+Fuchs AG, also apply to Pepperl+Fuchs SE.

PDF 파일로 된 데이타 시트 다운로드:

데이타 시트 발췌: 기술 사양 FB8210*

Supply
Connection		backplane bus
Rated voltage		5 V DC , only in connection with the power supplies FB92**
Power consumption		2 W
Auxiliary energy		24 V DC Trunk load 20 mA
Fieldbus connection
Fieldbus type		FOUNDATION Fieldbus H1
FOUNDATION Fieldbus
	Connection	wired to Ex e terminals via backplane
	Baud rate	31.25 kBit/s , MBP
	Protocol	H1 to IEC 1158-2
Station connection		directly at the trunk or via spur protector
Number of stations per bus line		1 or 2, depending on the required response times
Number of channels per station		max. 20 analog, max. 40 digital
Supported I/O modules		5 slots, to be filled with (combinations possible): 108 digital input, 8-channel, NAMUR 305 analog input, 4-channel, 20 mA (HART via service bus) 405 analog output, 4-channel, 20 mA (HART via service bus) 5204 Pt100 RTD input, 4-channel 5205 thermocouple input, 4-channel 6305 relay output, 4-channel, 230 V 6306 relay output, 8-channel, 24 V 608 digital output, 8-channel, Ex i 6210-6215 digital output, 4-channel, Ex i power * = variable (2=IS, 3=Ex e)
Bus length		max. 1900 m (must not be exceeded by the sum of all trunk and spur lines)
Spur length		max. 120 m (depending on the number of field devices. Modular I/O station = 1 field device)
Addressing		via PCS (software)
Internal bus
Connection		backplane bus
Indicators/settings
LED indicator		LED green (power supply): On = operating, fast flash = cold start LED red (collective alarm): On = internal fault, flashing = no fieldbus LED yellow (operating mode): Flashing = active
Directive conformity
Electromagnetic compatibility
	Directive 2014/30/EU	EN 61326-1
Conformity
Electromagnetic compatibility		NE 21
Degree of protection		IEC 60529
Ambient conditions
Ambient temperature		-20 ... 60 °C (-4 ... 140 °F)
Storage temperature		-25 ... 85 °C (-13 ... 185 °F)
Relative humidity		95 % non-condensing
Shock resistance		shock type I, shock duration 11 ms, shock amplitude 15 g, number of shocks 18
Vibration resistance		frequency range 10 ... 150 Hz; transition frequency: 57.56 Hz, amplitude/acceleration ± 0.075 mm/1 g; 10 cycles frequency range 5 ... 100 Hz; transition frequency: 13.2 Hz amplitude/acceleration ± 1 mm/0.7 g; 90 minutes at each resonance
Damaging gas		designed for operation in environmental conditions acc. to ISA-S71.04-1985, severity level G3
Mechanical specifications
Degree of protection		IP20 (module) , a separate housing is required acc. to the system description
Connection		via backplane
Mass		approx. 750 g
Dimensions		57 x 107 x 132 mm (2.2 x 4.2 x 5.2 inch)
Data for application in connection with hazardous areas
EU-Type Examination Certificate		PTB 97 ATEX 1074 U
	Marking	II 2 G Ex d IIC Gb
Directive conformity
	Directive 2014/34/EU	EN 60079-0:2009 EN 60079-1:2007 EN 60079-11:2007 EN 60079-26:2007 EN 61241-11:2006
International approvals
ATEX approval		PTB 97 ATEX 1075
EAC approval		Russia: RU C-IT.MIII06.B.00129
Marine approval
	Lloyd Register	15/20021
	DNV GL Marine	TAA0000034
	American Bureau of Shipping	T1450280/UN
	Bureau Veritas Marine	22449/B0 BV

Classifications

System	Classcode
ECLASS 13.0	27210121
ECLASS 12.0	27210121
ECLASS 11.0	27210121
ECLASS 10.0.1	27210121
ECLASS 9.0	27210121
ECLASS 8.0	27210121
ECLASS 5.1	27210121
ETIM 9.0	EC001485
ETIM 8.0	EC001485
ETIM 7.0	EC001485
ETIM 6.0	EC001485
ETIM 5.0	EC001485
UNSPSC 12.1	39121008

Details: FB8210*

Informative Literature: FB8210*

Literature	언어	파일 타입	파일 크기
Application Report - Communication Redundancy for Uninterrupted Operation	ENG	PDF	529 KB
Application Report - LB and FB Remote I/O Systems for Digitally Connecting Analog Field Devices	ENG	PDF	208 KB
Application Report - Space Saving Extension for Existing Plants	ENG	PDF	300 KB
Application Report - Using Remote I/O Systems for the Efficient Digitalization of Plants	ENG	PDF	371 KB

Product Documentation: FB8210*

System Descriptions	언어	파일 타입	파일 크기
Supported I/O modules	ENG	PDF	31 KB
Safety and Security Documentation
Instruction manual	ENG	PDF	51 KB
Manuals
Manual - FB-Remote-I/O-System	ENG	PDF	5670 KB
Manual FF ComUnit 8x10	ENG	PDF	1471 KB
Software Information
Software Product Note Remote I/O DTM / Softwareproduktschein Remote I/O DTM	ALL	PDF	256 KB

Design / Simulation: FB8210*

CAE	언어	파일 타입	파일 크기
CAE EPLAN Data Portal / CAE EPLAN Data Portal	ALL	LINK	---
CAE EPLAN macro EDZ / CAE EPLAN Makro EDZ	ALL	EDZ	103 KB

Approvals: FB8210*

Certificates	인증서 번호	언어	파일 타입	파일 크기
Bureau Veritas (Maritime) Marine	22449/C0 BV	ALL	PDF	590 KB
DNV Marine	TAA0000034	ALL	PDF	110 KB
Europe PTB ATEX Category 2 G	PTB 97 ATEX 1074U	ALL	PDF	2619 KB
Lloyd's Register Marine	LR2003616TA-02	ALL	PDF	557 KB
Worldwide Fieldbus Foundation	IT048400	ALL	PDF	149 KB